Product ID:SUPER QUADROLUBE 80W90 GEAR
MSDS Date:12/15/1994
FSC:9150
NIIN:01-035-5394
MSDS Number: BWPSZ

QUAKER STATE OIL REFINING CORP

255 ELM ST
OIL CITY, PA 16301-1412
US

Emergency Phone: 814-676-2726

Info Phone: 814-676-2726

Preparer: D.W. CRALLEY

Cage: DO899

QUAKER STATE OIL REFINING CORPORATION

OIL CITY, PA 16301 US

Telephone: 814-676-7676

Cage: DO899

MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT DEWAXED (MILD),

CAS: 64742-65-0

RTECS: PY8038500

Fraction By Weight: 25-30%

SOLVENT DEWAXED RESIDUAL OIL (PETROLEUM)

CAS: 64742-62-7

Fraction By Weight: 60-65%

OLEFIN SULFIDE

CAS: 72162-26-6

Fraction By Weight: 2-4%

ALKYLAMINE SALTS OF PHOSPHORIC ACID ESTERS

CAS: 71888-91-0

Fraction By Weight: 0-2%

Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:CONTACT MAY CAUSE EYE IRRITATION.
PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE IRRITATION OR
DERMATITIS. INHALATION OF HIGH CONCENTRATIONS OF MISTS OR VAPOR MAY
CAUSE UPPER RESPIRATORY TRACT IRRITATIO N; POSSIBLE CNS DEPRESSION.
ASPIRATION DURING SWALLOWING OR VOMITING MAY CAUSE PULMONARY
INJURY.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:EYES-REDNESS, BURNING SENSATION, TEARING.
SKIN-IRRITATION, DERMATITIS. INHALED-IRRITATION, DIZZINESS, NAUSEA,
HEADACHE, LOSS OF COORDINATION, WEAKNESS. INGESTED-PULMONARY
INJURY.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHALATION-REMOVE TO FRESH AIR. GIVE MOUTH-TO-MOUTH
RESUSCITATION IF NOT BREATHING. GET MEDICAL ATTENTION. EYE-FLUSH
WITH WATER FOR 15 MINUTES. GET MEDICAL ATTENTION IMMEDIATELY.
SKIN-WASH WITH SOAP & WATER. REMOVE CONTAMINATED CLOTHING.
INGESTION-DO NOT INDUCE VOMITING. NOTHING BY MOUTH IF UNCONSCIOUS.
GET MEDICAL ATTENTION.

Flash Point Method:COC
Flash Point:390F,199C
Extinguishing Media:WATER, CARBON DIXOIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE WATER SPRAY TO COOL FIRE-EXPOSED
CONTAINERS AND AS A PROTECTIVE SCREEN. DO NOT POINT WATER STREAM
DIRECTLY AT BURNING OIL, IT MAY SPREAD THE FIRE.
Unusual Fire/Explosion Hazard:"EMPTY" CONTAINERS RETAIN PRODUCT RESIDUE
AND CAN BE DANGEROUS.

Spill Release Procedures:ABSORB WITH INERT MATERIALS SUCH AS DRY CLAY,
SAND, DIATOMACEOUS EARTH, OR RECOVER WITH PUMPS. SCOOP UP USED
ABSORBENT INTO DRUMS. DO NOT ALLOW INTO PUBLIC DRAINAGE SYSTEM OR
OPEN WATERWAYS. WEAR APPR OPRIATE CLOTHING/EQUIPMENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE AWAY FROM STRONG OXIDIZING
AGENTS.
Other Precautions:EMPTY DRUMS SHOULD BE COMPLETELY DRAINED, PROPERLY
BUNGED & PROMPTLY RETURNED TO A DRUM RECONDITIONER OR PROMPTLY
DISPOSED OF.

Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR EMERGENCY OCCURS; USE NIOSH/MSHA APPROVED RESPIRATOR OR SUPPLIED
AIR RESPIRATOR OR SCBA, AS REQUIRED. USE IAW 29 CFR 1910.134 AND
MANUFACTURER'S RECO MMENDATIONS.
Ventilation:USE GENERAL VENTILATION AND USE LOCAL EXHAUST WHERE
POSSIBLE IN CONFINED OR ENCLOSED SPACES.
Protective Gloves:NITRILE, VITON.
Eye Protection:NONE NORMALLY REQUIRED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS:
EYE WASH STATION & SAFETY SHOWER AVAILABLE FOR EMERGENCY USE.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health

HCC:V6
Spec Gravity:0.88-0.90
Viscosity:674 SUS @100F
Appearance and Odor:BROWN, VISCOUS LIQUID.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS (SUCH AS CHLORINE, PEROXIDES), STRONG ACIDS.
Stability Condition to Avoid:EXCESSIVE HEAT, FORMATION OF MISTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF SULFUR, NITROGEN, BORON AND PHOSPHOROUS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:MATERIAL, IF DISCARDED, IS NOT EXPECTED TO BE A
CHARACTERISTIC WASTE UNDER RCRA. USED OIL CAN BE RETURNED TO A
COLLECTION POINT OR PROVIDED TO A LICENSED RECYCLER. ALL WASTES
MUST BE HANDLED IAW LOCAL , STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.